Carter-hoffmann PH1890 User Manual download pdf

For PH1870 & PH1890

Heated Transport Carts

Cleaning, Operating, Maintenance Instructions, Parts List & Warranty

Cleansers, detergents,

degreasers, sanitizers

or bleaching agents

that contain chlorides

or phosphates will

cause permanent damage to stainless

steel products. The damage appears

as pits, eruptions, voids, small holes,

cracks, severe discoloration, or dulling

of the metal finish. Water with high

chloride content can also damage

stainless steel. If you are uncertain of

your water quality, we recommend you

have it tested. THIS DAMAGE IS

PERMANENT, COSTLY TO

REPAIR, AND IS NOT COVERED

BY THE WARRANTY.

CAUTION

Be sure the cabinet is

unplugged and cool

before cleaning. The

heater components

should not be exposed

to direct contact with water or cleaning

sprays. Permanent damage to the

electrical components will result.

WARNING

1. After all food products and containers have been removed from the cabinet, turn the

power switch to “OFF.” Allow the cabinet to cool.

2. Unplug and remove the SHU heating unit from the rear of the cabinet.

3. Wipe down interior & exterior surface with soap and water. Never use abrasive

cleaners, waxes, car polish, or substances containing strong aromatic solvents or

alcohol. Caution: When using solvents, it is essential that proper precautionary

measures be observed. Refer to solvent manufacturer’s instructions.

4. To clean stainless steel surfaces, use only cleansers, detergents, degreasers, or

sanitizers that are certified to be “chloride-free” and “phosphate-free.” Use these

products only in recommended concentrations. DO NOT exceed recommended

concentrations or mixing ratios. After

cleaning and sanitizing, rinse all exposed

surfaces thoroughly with large amounts of

clean, clear water. Wipe off any standing

liquid or residue from all surfaces,

corners, or near edges.

5. Rinse thoroughly with clear water and

allow to dry.

Installation

Purpose Frequency Cleaning Agent Method of Application

Routine Daily Soap, ammonia detergent Sponge with cloth, rinse with clear water and wipe dry.

cleaning and water

Smears/ As Needed Stainless steel cleaner Rub with cloth as directed on package. Rub in direction of grain

finger prints or similar products of stainless steel. Do not use on vinyl trim or adhesive labels.

Stubborn Daily Any chloride-free Apply with damp sponge or cloth. Rub in direction of polish

spots and As Needed or phosphate-free lines. Rinse thoroughly after use, especially if cleaner contains

stains cleaner chlorine bleach. Do not use on vinyl trim or adhesive labels.

Hard water Daily Vinegar Swab with cloth. Rinse with water and wipe dry.

spots As Needed

RECOMMENDED TIPS FOR CLEANING STAINLESS STEEL

NOTE: This equipment has been designed and manufactured to meet all applicable

health and safety codes and will give years of dependable service if used properly. All

cabinets should be thoroughly cleaned before using.

1. Remove the cabinet from its shipping carton and make sure that all packing

materials are removed from the cabinet.

2. Read this equipment manual completely before operating cabinet.

3. Locate cabinet on a dry, level surface. Set caster brakes to prevent accidental

movement of cabinet.

4. Clean cabinet thoroughly before operation (see instructions below).

5. Connect the cabinet power cord to a correctly-wired and protected power source.

Cleaning Instructions

Do not plug into

ungrounded receptacle.

Check to ensure that

heater plug is in safe

operating condition.

WARNING

NO!

PH1870 PH1890

1 2 3 4

Summary of Contents

Page 1 - Cleaning Instructions

For PH1870 & PH1890Heated Transport CartsCleaning, Operating, Maintenance Instructions, Parts List & WarrantyCleansers, detergents,degreasers,

Page 2 - Calibrations

Heater/CabinetOperationsCalibrationsDo not locate thisunit under an over-head ventilationsystem or close toother cookingequipment. Fumes and grease pa

Page 3 - Instructions

3MaintenanceInstructionsWiring DiagramCASTERSSome casters are equipped with ZERK grease fittings so that they may be easilylubricated with a grease gu

Page 4 - Warranty Information

Contact factory with your model and serial number for replacement parts and service.Tel 847.362.5500 or Toll Free 800.323.9793 Carter-Hoffmann Warran

Related models: PH1870

Comments to this Manuals

No comments

Carter-hoffmann PH1890 User Manual

Browse online or download User Manual for Kitchen Carter-hoffmann PH1890. Carter-Hoffmann PH1890 User Manual

Summary of Contents

Related models: PH1870

Comments to this Manuals

Related products and manuals for Kitchen Carter-hoffmann PH1890